Glossary entry (derived from question below)
English term or phrase:
Caging (brakes)
Polish translation:
zwolnienie hamulca (przez zwolnienie napięcia sprężyny w komorze hamulcowej)
Added to glossary by
Frank Szmulowicz, Ph. D.
Feb 6, 2019 16:12
5 yrs ago
6 viewers *
English term
Caging (brakes)
English to Polish
Tech/Engineering
Mechanics / Mech Engineering
Obsługa samochodów ciężarowych
Jakim polskim terminem określa się tę czynność, w tym przypadku wykonywaną pod naczepą unieruchomionego w wypadku zestawu przed jego odholowaniem?
Proposed translations
(Polish)
2 | zwolnienie hamulca (przez zwolnienie napięcia sprężyny w komorze hamulcowej) | Frank Szmulowicz, Ph. D. |
1 +1 | odblokowanie hamulców pneumatycznych (śrubą blokującą) | geopiet |
Change log
Mar 5, 2019 19:04: Frank Szmulowicz, Ph. D. Created KOG entry
Proposed translations
1 hr
Selected
zwolnienie hamulca (przez zwolnienie napięcia sprężyny w komorze hamulcowej)
Definicja na podstawie opisu
Caging brakes is only done when an air brake system failure has happened and you need to get your unit to a safe haven only, not normal operation. This procedure releases the spring tension within the brake chamber and will render that wheel with no brakes when completed.
https://www.teamrunsmart.com/articles/truck-smart/june-2014/...
https://www.slideshare.net/TerryPenney/cage-bolt-procedures-...
Caging brakes is only done when an air brake system failure has happened and you need to get your unit to a safe haven only, not normal operation. This procedure releases the spring tension within the brake chamber and will render that wheel with no brakes when completed.
https://www.teamrunsmart.com/articles/truck-smart/june-2014/...
https://www.slideshare.net/TerryPenney/cage-bolt-procedures-...
4 KudoZ points awarded for this answer.
Comment: "Dziękuję za pomoc. "
+1
18 hrs
odblokowanie hamulców pneumatycznych (śrubą blokującą)
Mechanical Release (Caging The Brake)
WARNING: Do not mechanically release (cage) the spring if there is any structural damage to the brake actuator.
Caging the spring in such a chamber may cause serious injury or death.
- http://www.tttonline.com/downloads/tech_bulletins/springbrak... - page 2
--------
When caging brake air chamber, do not remove flange nuts (1) or bolts (2) . High spring pressure inside air chamber can cause injury if released.
NOTE
Caging the brake air chamber (steps (1) thru (5)) applies only to rear brakes .
(1) Cage brake air chamber by removing nut (3) and washer (4) and release stud (5) from mounting bracket on brake air chamber (6).
(2) Remove plug (7).
(3) Insert T-end of release stud (5) into chamber hole and turn one-quarter turn clockwise to engage stud in pressure plate.
(4) Install washer (4) and nut (3) on release stud (5) and tighten nut until wheel spins freely .
(5) Repeat steps (1) thru (4) to cage remaining brake air chamber, if necessary
http://imfmotorpool.com/069300 - page 76
------
Wśliznąłem się pod podwozie i spostrzegłem, że moja nadzieja mnie nie zawiodła. Wsadziłem śrubę blokującą ( caging bolt) i nałożywszy grzechotkę odblokowałem hamulec. Samoblokującymi się szczypcami ścisnąłem uszkodzony przewód, którym uciekało powietrze z układu - https://arcticknight.org/2019/02/01/na-ratunek/
WARNING: Do not mechanically release (cage) the spring if there is any structural damage to the brake actuator.
Caging the spring in such a chamber may cause serious injury or death.
- http://www.tttonline.com/downloads/tech_bulletins/springbrak... - page 2
--------
When caging brake air chamber, do not remove flange nuts (1) or bolts (2) . High spring pressure inside air chamber can cause injury if released.
NOTE
Caging the brake air chamber (steps (1) thru (5)) applies only to rear brakes .
(1) Cage brake air chamber by removing nut (3) and washer (4) and release stud (5) from mounting bracket on brake air chamber (6).
(2) Remove plug (7).
(3) Insert T-end of release stud (5) into chamber hole and turn one-quarter turn clockwise to engage stud in pressure plate.
(4) Install washer (4) and nut (3) on release stud (5) and tighten nut until wheel spins freely .
(5) Repeat steps (1) thru (4) to cage remaining brake air chamber, if necessary
http://imfmotorpool.com/069300 - page 76
------
Wśliznąłem się pod podwozie i spostrzegłem, że moja nadzieja mnie nie zawiodła. Wsadziłem śrubę blokującą ( caging bolt) i nałożywszy grzechotkę odblokowałem hamulec. Samoblokującymi się szczypcami ścisnąłem uszkodzony przewód, którym uciekało powietrze z układu - https://arcticknight.org/2019/02/01/na-ratunek/
Peer comment(s):
agree |
Paweł Janiszewski
: Zgadzam się. Tyle, że bez tej "śruby blokującej", bo termin wprowadza trochę w błąd - śruba blokuje sprężynę, ale jednocześnie odblokowuje hamulec. Patrz materiały referencyjne.
4 days
|
Reference comments
28 mins
Reference:
caging
How-to:
https://www.youtube.com/watch?v=dwmt3zuRoYA
Caging brakes is only done when an air brake system failure has happened and you need to get your unit to a safe haven only, not normal operation. This procedure releases the spring tension within the brake chamber and will render that wheel with no brakes when completed.
https://www.teamrunsmart.com/articles/truck-smart/june-2014/...
https://www.youtube.com/watch?v=dwmt3zuRoYA
Caging brakes is only done when an air brake system failure has happened and you need to get your unit to a safe haven only, not normal operation. This procedure releases the spring tension within the brake chamber and will render that wheel with no brakes when completed.
https://www.teamrunsmart.com/articles/truck-smart/june-2014/...
5 days
Reference:
caging brake chambers
Na poniższych filmach przepięknie widać, na czym to polega:
1) w warunkach „laboratoryjnych":
https://www.youtube.com/watch?v=XVmRCPSVQrM
2) w warunkach polowych:
https://www.youtube.com/watch?v=dwmt3zuRoYA
--------------------------------------------------
Note added at 5 days (2019-02-12 09:59:27 GMT)
--------------------------------------------------
A tutaj po polsku:
https://youtu.be/rOZGWPHv_5M?t=289
Kierowca używa zwrotu „musimy odblokować hamulec".
1) w warunkach „laboratoryjnych":
https://www.youtube.com/watch?v=XVmRCPSVQrM
2) w warunkach polowych:
https://www.youtube.com/watch?v=dwmt3zuRoYA
--------------------------------------------------
Note added at 5 days (2019-02-12 09:59:27 GMT)
--------------------------------------------------
A tutaj po polsku:
https://youtu.be/rOZGWPHv_5M?t=289
Kierowca używa zwrotu „musimy odblokować hamulec".
Something went wrong...